How to service and repair the A/C Clutch on Toyota RAV4?

Commence compressor clutch service and repair operations by operating the engine at idle and enabling air conditioning mode for 10 minutes before shutting down the power source then removing the negative cable from the battery. First remove the drive belt then drain refrigerant from the cooling system and take away the RH front engine under cover. The system must be protected from moisture and dirt contamination through capping of open fittings after removing two discharge hose bolts. Separate the compressor by disconnecting its connector followed by unscrewing the 3 bolts and nut and stud bolt while maintaining the discharge and suction hose intact. The installation process requires fitting the compressor onto its mounting points by inserting the 3 bolts and nut and stud bolt. First, tighten Bolt A lightly then use your palm to push the rear compressor section downwards while proceeding with full torques of 24.5 Nm (250 kgf-cm, 18 ft-lbf) on Bolt B then nut and bolt C and finally Bolt A. Attach the connector and apply compressor oil to two newly installed O-rings. Place these rings into the hoses before connecting them with the torqued-to-9.8 N.m (100 kg.cm, 87 in.lb) 2 bolts. The installation of a new compressor requires a 100cc (3.5 fl.oz.) addition of ND-OIL 8 or an equivalent compressor oil. After hooking up the hose caps, immediately attach the hoses while avoiding any harm to the discharge and suction hose. After installing the drive belt follow up with negating the battery terminal connection and proceed to purify the refrigeration system using an air pump while charging it with 500 plus or minus 50 g (17.64 plus or minus 1.76 oz.) refrigerant. The technician should utilize a gas leak detector to identify any evidence of refrigerant leakage before checking the joint torque standards and conducting A/C operational examination.

OEM Toyota RAV4 A/C Clutch

Air Conditioning Clutch

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

16 A/C Clutches found

View related parts
Toyota RAV4 Clutch & Pulley
Part Number: 88410-42080
$231.01 MSRP: $329.83
You Save: $98.82 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Clutch Assembly, Magnet; A/C Compressor Clutch; Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2004-2005 Toyota RAV4 | Base, L, Sport | 4 Cyl 2.4 L GAS
View related parts
Toyota RAV4 Clutch Assembly
Part Number: 88410-33150
$175.20 MSRP: $250.16
You Save: $74.96 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: A/C Compressor Clutch; Clutch & Pulley; Clutch; Clutch Assembly, Magnet
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2006-2012 Toyota RAV4 | Base, Limited, Sport | 6 Cyl 3.5 L GAS
View related parts
Toyota RAV4 Hub Sub-Assembly, Magnet Clutch
Part Number: 88403-32010
$133.43 MSRP: $188.90
You Save: $55.47 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hub Sub-Assembly, Magnet; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2001-2005 Toyota RAV4 | Base, L, Sport | 4 Cyl 2.0 L GAS, 4 Cyl 2.4 L GAS
View related parts
Toyota RAV4 Clutch Coil
Part Number: 88411-02030
$138.83 MSRP: $196.53
You Save: $57.70 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Stator, Magnet Clutch; A/C Compressor Clutch Coil; Magnet; Coil; Stator Sub-Assembly, Magnet Clutch; A/C Compressor Clutch
- Replaces: 88411-2A030, 88411-22310, 88411-0C010, 88411-04010
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1998-2000 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Clutch & Pulley
Part Number: 88410-42090
$190.47 MSRP: $271.95
You Save: $81.48 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Clutch Assembly, Magnet; A/C Compressor Clutch; Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2013-2018 Toyota RAV4 | Adventure, Hybrid Limited, Hybrid SE, Hybrid XLE, LE, Limited, Platinum, SE, XLE | 4 Cyl 2.5 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 2.5 L GAS
View related parts
Toyota RAV4 Clutch & Pulley
Part Number: 88410-42040
$186.62 MSRP: $266.45
You Save: $79.83 (30%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Clutch Assembly, Magnet; A/C Compressor Clutch; Clutch
- Replaces: 88410-06080
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2001-2003 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Clutch Coil
Part Number: 88411-44010
$115.51 MSRP: $162.14
You Save: $46.63 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Stator, Magnet Clutch; A/C Compressor Clutch Coil; Magnet; Coil; Stator; Stator Sub-Assembly, Magnet Clutch; A/C Compressor Clutch
- Replaces: 88411-06050
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2001-2003 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Rotor
Part Number: 88412-44010
$330.34 MSRP: $471.64
You Save: $141.30 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Magnet Clutch; A/C Compressor Clutch Pulley; Rotor Sub-Assembly, Magnet Clutch; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1998-2000 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Pulley
Part Number: 88412-42010
$327.99 MSRP: $468.29
You Save: $140.30 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Magnet Clutch; A/C Compressor Clutch Drive; Rotor; Rotor Sub-Assembly, Magnet Clutch; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2001-2003 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Rotor
Part Number: 88412-2A010
$293.03 MSRP: $418.39
You Save: $125.36 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Magnet Clutch; A/C Compressor Clutch Pulley; Rotor Sub-Assembly, Magnet Clutch; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1996-1997 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Clutch
Part Number: 88410-44010
$603.54 MSRP: $884.50
You Save: $280.96 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Clutch Assembly, Magnet; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1998-2000 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Clutch & Pulley
Part Number: 88410-0R010
$488.69 MSRP: $716.18
You Save: $227.49 (32%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Clutch Assembly, Magnet; A/C Compressor Clutch; Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 2013-2018 Toyota RAV4 | Adventure, Hybrid Limited, Hybrid SE, Hybrid XLE, LE, Limited, Platinum, SE, XLE | 4 Cyl 2.5 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 2.5 L GAS
View related parts
Toyota RAV4 Hub Sub-Assembly, Magnet Clutch
Part Number: 88403-06050
Product Specifications
- Other Name: Hub Sub-Assembly, Magnet; A/C Compressor Clutch
- Replaces: 88403-30290
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1998-2000 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Clutch Coil
Part Number: 88411-42010
Product Specifications
- Other Name: Stator, Magnet Clutch; A/C Compressor Clutch Coil; Magnet; Stator Sub-Assembly, Magnet Clutch; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1996-1997 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Clutch
Part Number: 88410-42010
Product Specifications
- Other Name: Clutch Assembly, Magnet; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1996-1997 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS
View related parts
Toyota RAV4 Clutch Plate & Hub Assembly
Part Number: 88403-12030
Product Specifications
- Other Name: Hub Sub-Assembly, Magnet Clutch; A/C Compressor Clutch Drive; Hub; A/C Compressor Clutch
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
Fits the following Vehicles:
- 1996-1997 Toyota RAV4 | Base | 4 Cyl 2.0 L GAS

Toyota RAV4 A/C Clutch

Choose genuine A/C Clutch that pass strict quality control tests. You can trust the top quality and lasting durability. Shopping for OEM A/C Clutch for your Toyota RAV4? Our website is your one-stop destination. We stock an extensive selection of genuine Toyota RAV4 parts. The price is affordable so you can save more. It only takes minutes to browse and find the exact fit. Easily add to cart and check out fast. Our hassle-free return policy will keep you stress-free. We process orders quickly for swift delivery. Your parts will arrive faster, so you can get back on the road sooner.

Toyota RAV4 A/C Clutch plays a significant role in vehicles' air conditioning systems; it has a reputation for being highly reliable and functioning well in numerous RAV4 models. This A/C Clutch that is incorporated in any car will effectively change the energy of the engine into usable power needed to run the A/C compressor as the clutch connects when the A/C is turned on. Within the belt pulley, if a drum is made magnetic, the Toyota RAV4 A/C Clutch secures the belt drive and allows for efficiency when engaged and reduces the engine's stress when disengaged. This feature does more than just increase the effectiveness of the A/C system while at the same time increases the safety and durability of the automobile. The Toyota RAV4 model has gone through generation changes since it first began in 1994, and so has the A/C Clutch to suit each generation, beginning with the small compact cross-over, to the modern hybrid systems of the current generations. Importantly, the A/C Clutch is free of sticking or slipping that often affects the efficiency of the A/C and raises the standard of fuel consumption. The Toyota RAV4 A/C Clutch distinguishes itself competitively in aspects of construction and reliability to allow the intended driver to have optimal control even of the climate within the car's cabin. Due to the versatile fitting method for the Toyota RAV4 model, the Toyota A/C Clutch can still safely be named one of the car's key characteristics.

Toyota RAV4 A/C Clutch Parts and Q&A

Hub Sub-Assembly, Magnet Clutch
88403-32010
Q: How to service and repair the A/C Clutch on Toyota RAV4?
A:
Commence compressor clutch service and repair operations by operating the engine at idle and enabling air conditioning mode for 10 minutes before shutting down the power source then removing the negative cable from the battery. First remove the Drive Belt then drain refrigerant from the cooling system and take away the RH front engine under cover. The system must be protected from moisture and dirt contamination through capping of open fittings after removing two discharge hose bolts. Separate the compressor by disconnecting its connector followed by unscrewing the 3 bolts and nut and stud bolt while maintaining the discharge and suction hose intact. The installation process requires fitting the compressor onto its mounting points by inserting the 3 bolts and nut and stud bolt. First, tighten Bolt A lightly then use your palm to push the rear compressor section downwards while proceeding with full torques of 24.5 Nm (250 kgf-cm, 18 ft-lbf) on Bolt B then nut and bolt C and finally Bolt A. Attach the connector and apply compressor oil to two newly installed O-rings. Place these rings into the hoses before connecting them with the torqued-to-9.8 N.m (100 kg.cm, 87 in.lb) 2 bolts. The installation of a new compressor requires a 100cc (3.5 fl.oz.) addition of ND-OIL 8 or an equivalent compressor oil. After hooking up the hose caps, immediately attach the hoses while avoiding any harm to the discharge and suction hose. After installing the drive belt follow up with negating the battery terminal connection and proceed to purify the refrigeration system using an air pump while charging it with 500 plus or minus 50 g (17.64 plus or minus 1.76 oz.) refrigerant. The technician should utilize a gas leak detector to identify any evidence of refrigerant leakage before checking the joint torque standards and conducting A/C operational examination.

Related Toyota RAV4 Parts

Browse Toyota RAV4 A/C Clutch by Years

2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2008 2007 2006 2005 2004 2003 2002 2001 2000 1999 1998 1997 1996