What is the proper procedure for activating and disposing of a front seat outer belt with a seat belt pretensioner using Special Service Tool 09082-00700, both when installed and when removed on 2009 Toyota Tundra?

The first procedure when handling seat belt pretensioner-equipped vehicles or front seat outer belts with built-in pretensioners must involve activating the pretensioner system prior to further work. Contact the service department of Toyota Motor Sales U.S.A. Inc for assistance if any abnormality occurs during activation. Tossing a front seat outer belt that possesses non-activated pretensioner is prohibited since activation produces a loud noise. When activating pretensioners on front seat outer belts it is vital to stand at least 10 meters (32.8 feet) from the seat and wear gloves and safety glasses. The procedure requires hand washing with water after disposal followed by strict avoidance of water application to pretensioners. Activation procedures need to be done in areas without electrical interference while using the special service tool (SST: 09082-00700). For proper disposal of the front seat outer belt assembly while in the vehicle you must first activate the pretensioner by connecting the SST to a battery with the red clip attached to the positive terminal and the black clip to the negative terminal but always verify that the yellow connector remains disconnected. The SST activation switch can be used to activate the LED light; if an LED glows without switching activation then change the SST unit. Disconnect the pretensioner connector while removing important trim pieces and then set up the SST by attaching the floor anchor followed by connection of the air bag deployment tool to the seat belt pretensioner. Activate the pretensioner and conduct the motion at least ten meters away from the vehicle while confirming no personnel remain in the designated ten-meter zone. It is essential to dispose of the front seat outer belt after pretensioner activation while avoiding contact with it for at least 30 minutes as the component remains hot. Dispose of seat belts away from vehicle installation by winding them with retractors, performing a 100mm cut from retractors to check SST operations then linking the air bag deployment tool to the pretensioner before placing the belt over tire-covered terrain at least 10m away from the SST location. Perform a pretensioner activation while watching from at least a 10 m distance and then remove the tire and SST before placing the tied front seat outer belt into a plastic bag for disposal among other general parts.

OEM 2009 Toyota Tundra Seat Belt

Seat Safety Belt

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

69 Seat Belts found

View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Black, Passenger Side
Part Number: 73210-0C081-C1
$253.49 MSRP: $361.93
You Save: $108.44 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Right; Retractor Assembly; Belt & Retractor; Belt Assembly, Front Seat Outer, Passenger Side
- Manufacturer Note: BLACK,TRIM2#
- Position: Passenger Side
- Replaces: 73210-0C081-C4
- Part Name Code: 73210
- Item Weight: 2.30 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73210-0C081-C1
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Black, Outer
Part Number: 73360-0C071-C2
$135.35 MSRP: $191.61
You Save: $56.26 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Rear Seat; Seat Belt Lap and Shoulder Belt, Rear Left, Rear Right; Outer Belt Assembly; Belt Assembly, Rear Seat, Outer
- Position: Outer
- Item Weight: 2.40 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73360-0C071-C2
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- 1794 Edition, Base, Limited, Platinum, SR, SR5, TRD Pro | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Gray, Center
Part Number: 73301-0C050-B0
$149.21 MSRP: $211.23
You Save: $62.02 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Sub-Assembly, Seat; Seat Belt Lap and Shoulder Belt, Rear Center; Center Seat Belt; Belt Assembly, Rear Seat, Outer Center
- Manufacturer Note: GRAY,TRIM1#
- Position: Center
- Part Name Code: 73350C
- Item Weight: 2.40 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73301-0C050-B0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, Platinum, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Black, Center
Part Number: 73301-0C050-C0
$150.27 MSRP: $212.72
You Save: $62.45 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Sub-Assembly, Seat; Seat Belt Lap and Shoulder Belt, Rear Center; Center Seat Belt; Belt Assembly, Rear Seat, Outer Center
- Manufacturer Note: BLACK,TRIM2#
- Position: Center
- Part Name Code: 73350C
- Item Weight: 2.50 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73301-0C050-C0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, Platinum, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Buckle End, Gray, Inner Driver Side
Part Number: 73390-0C010-B0
$24.84 MSRP: $34.58
You Save: $9.74 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Rear Seat; Seat Belt Receptacle, Rear Left Outer; Latch; Belt Assembly, Rear Seat, Inner Driver Side
- Manufacturer Note: GRAY,TRIM1#
- Position: Inner Driver Side
- Part Name Code: 73390C
- Item Weight: 1.40 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73390-0C010-B0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, Platinum, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Buckle End, Black, Driver Side
Part Number: 73240-0C080-C0
$47.43 MSRP: $66.02
You Save: $18.59 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Receptacle, Front Left; Latch; Belt Assembly, Front Seat Inner, Driver Side
- Position: Driver Side
- Part Name Code: 73240
- Item Weight: 1.00 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73240-0C080-C0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Sand, Passenger Side
Part Number: 73210-0C091-A0
$246.91 MSRP: $352.53
You Save: $105.62 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Right; Retractor Assembly; Belt Assembly, Front Seat Outer, Passenger Side
- Manufacturer Note: SAND BEIGE,TRIM4#
- Position: Passenger Side
- Part Name Code: 73210
- Item Weight: 3.10 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73210-0C091-A0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Black, Passenger Side
Part Number: 73210-0C091-C0
$246.91 MSRP: $352.53
You Save: $105.62 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Right; Retractor Assembly; Belt Assembly, Front Seat Outer, Passenger Side
- Manufacturer Note: NUMBER OF PASSENGER-FRONT:2,BLACK,TRIM2#
- Position: Passenger Side
- Part Name Code: 73210
- Item Weight: 3.30 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73210-0C091-C0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Black, Driver Side
Part Number: 73220-0C091-C0
$246.91 MSRP: $352.53
You Save: $105.62 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Left; Retractor Assembly; Belt Assembly, Front Seat Outer, Driver Side
- Manufacturer Note: NUMBER OF PASSENGER-FRONT:2,BLACK,TRIM2#
- Position: Driver Side
- Part Name Code: 73220
- Item Weight: 3.30 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73220-0C091-C0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Gray, Passenger Side
Part Number: 73210-0C081-B2
$269.80 MSRP: $385.21
You Save: $115.41 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Right; Retractor Assembly; Belt & Retractor; Belt Assembly, Front Seat Outer, Passenger Side
- Manufacturer Note: GRAY,TRIM1#
- Position: Passenger Side
- Replaces: 73210-0C081-B3
- Part Name Code: 73210
- Item Weight: 4.10 Pounds
- Item Dimensions: 10.2 x 7.2 x 6.4 inches
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73210-0C081-B2
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Beige, Passenger Side
Part Number: 73210-0C081-E1
$269.80 MSRP: $385.21
You Save: $115.41 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Right; Retractor Assembly; Belt & Retractor; Belt Assembly, Front Seat Outer, Passenger Side
- Manufacturer Note: SAND BEIGE,TRIM4#
- Position: Passenger Side
- Replaces: 73210-0C081-A0
- Part Name Code: 73210
- Item Weight: 2.40 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73210-0C081-E1
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Gray, Passenger Side
Part Number: 73210-0C091-B2
$264.91 MSRP: $378.23
You Save: $113.32 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Right; Retractor Assembly; Belt Assembly, Front Seat Outer, Passenger Side
- Manufacturer Note: GRAY,TRIM1#
- Position: Passenger Side
- Part Name Code: 73210
- Item Weight: 3.20 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73210-0C091-B2
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Gray, Driver Side
Part Number: 73220-0C081-B2
$269.80 MSRP: $385.21
You Save: $115.41 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Left; Retractor Assembly; Belt & Retractor; Belt Assembly, Front Seat Outer, Driver Side
- Position: Driver Side
- Replaces: 73220-0C081-B3
- Part Name Code: 73220
- Item Weight: 4.10 Pounds
- Item Dimensions: 10.5 x 7.3 x 6.3 inches
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73220-0C081-B2
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Sand, Driver Side
Part Number: 73220-0C091-A0
$253.49 MSRP: $361.93
You Save: $108.44 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Left; Retractor Assembly; Belt Assembly, Front Seat Outer, Driver Side
- Manufacturer Note: SAND BEIGE,TRIM4#
- Position: Driver Side
- Part Name Code: 73220
- Item Weight: 3.10 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73220-0C091-A0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Gray, Driver Side
Part Number: 73220-0C091-B2
$253.49 MSRP: $361.93
You Save: $108.44 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Left; Retractor Assembly; Belt Assembly, Front Seat Outer, Driver Side
- Manufacturer Note: GRAY,TRIM1#
- Position: Driver Side
- Part Name Code: 73220
- Item Weight: 2.50 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73220-0C091-B2
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Black, Passenger Side
Part Number: 73301-0C041-C0
$135.11 MSRP: $191.27
You Save: $56.16 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Sub-Assembly, Seat; Seat Belt Lap and Shoulder Belt, Front Center; Center Belt Assembly; Seat Belt Assembly, Front Center, Passenger Side
- Position: Passenger Side
- Part Name Code: 73160A
- Item Weight: 2.60 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73301-0C041-C0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- 1794 Edition, Base, Limited, Platinum, SR, SR5, TRD Pro | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Gray, Passenger Side
Part Number: 73301-0C041-B0
$150.27 MSRP: $212.72
You Save: $62.45 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Sub-Assembly, Seat; Seat Belt Lap and Shoulder Belt, Front Center; Center Belt Assembly; Seat Belt Assembly, Front Center, Passenger Side
- Manufacturer Note: GRAY,TRIM1#
- Position: Passenger Side
- Part Name Code: 73160A
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73301-0C041-B0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, Platinum, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Sand, Passenger Side
Part Number: 73301-0C041-E0
$140.40 MSRP: $198.75
You Save: $58.35 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Sub-Assembly, Seat; Seat Belt Lap and Shoulder Belt, Front Center; Center Belt Assembly; Seat Belt Assembly, Front Center, Passenger Side
- Manufacturer Note: SAND BEIGE,TRIM4#
- Position: Passenger Side
- Part Name Code: 73160A
- Item Weight: 2.80 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73301-0C041-E0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, Platinum, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Gray, Center
Part Number: 73301-0C062-B0
$149.21 MSRP: $211.23
You Save: $62.02 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Belt Sub-Assembly, Seat; Seat Belt Lap and Shoulder Belt, Rear Center; Center Seat Belt; Belt Assembly, Rear Seat, Outer Center
- Manufacturer Note: GRAY,TRIM1#
- Position: Center
- Part Name Code: 73350C
- Item Weight: 2.60 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73301-0C062-B0
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, Platinum, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.6 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS
View related parts
2009 Toyota Tundra Lap & Shoulder Belt, Black, Driver Side
Part Number: 73220-0C081-C1
Product Specifications
- Other Name: Belt Assembly, Front Seat; Seat Belt Lap and Shoulder Belt, Front Left; Retractor Assembly; Belt & Retractor; Belt Assembly, Front Seat Outer, Driver Side
- Position: Driver Side
- Replaces: 73220-0C081-C4
- Part Name Code: 73220
- Item Weight: 2.30 Pounds
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 73220-0C081-C1
- Warranty: This genuine part is guaranteed by Toyota's factory warranty.
More Info
Fits the following 2009 Toyota Tundra Submodels:
- Base, Limited, SR5 | 6 Cyl 4.0 L GAS, 8 Cyl 4.7 L GAS, 8 Cyl 5.7 L FLEX, 8 Cyl 5.7 L GAS

| Page 1 of 4 |Next >

1-20 of 69 Results

2009 Toyota Tundra Seat Belt

Looking for affordable OEM 2009 Toyota Tundra Seat Belt? Explore our comprehensive catalogue of genuine 2009 Toyota Tundra Seat Belt. All our parts are covered by the manufacturer's warranty. Plus, our straightforward return policy and speedy delivery service ensure an unparalleled shopping experience. We look forward to your visit!

2009 Toyota Tundra Seat Belt Parts Q&A

Q: What is the proper procedure for activating and disposing of a front seat outer belt with a seat belt pretensioner using Special Service Tool 09082-00700, both when installed and when removed on 2009 Toyota Tundra?
A: The first procedure when handling seat belt pretensioner-equipped vehicles or front seat outer belts with built-in pretensioners must involve activating the pretensioner system prior to further work. Contact the service department of Toyota Motor Sales U.S.A. Inc for assistance if any abnormality occurs during activation. Tossing a front seat outer belt that possesses non-activated pretensioner is prohibited since activation produces a loud noise. When activating pretensioners on front seat outer belts it is vital to stand at least 10 meters (32.8 feet) from the seat and wear gloves and safety glasses. The procedure requires hand washing with water after disposal followed by strict avoidance of water application to pretensioners. Activation procedures need to be done in areas without electrical interference while using the special service tool (SST: 09082-00700). For proper disposal of the front seat outer belt assembly while in the vehicle you must first activate the pretensioner by connecting the SST to a battery with the red clip attached to the positive terminal and the black clip to the negative terminal but always verify that the yellow connector remains disconnected. The SST activation switch can be used to activate the LED light; if an LED glows without switching activation then change the SST unit. Disconnect the pretensioner connector while removing important trim pieces and then set up the SST by attaching the floor anchor followed by connection of the air bag deployment tool to the seat belt pretensioner. Activate the pretensioner and conduct the motion at least ten meters away from the vehicle while confirming no personnel remain in the designated ten-meter zone. It is essential to dispose of the front seat outer belt after pretensioner activation while avoiding contact with it for at least 30 minutes as the component remains hot. Dispose of seat belts away from vehicle installation by winding them with retractors, performing a 100mm cut from retractors to check SST operations then linking the air bag deployment tool to the pretensioner before placing the belt over tire-covered terrain at least 10m away from the SST location. Perform a pretensioner activation while watching from at least a 10 m distance and then remove the tire and SST before placing the tied front seat outer belt into a plastic bag for disposal among other general parts.

Related 2009 Toyota Tundra Parts

Alternate Year Models

2008 Toyota Tundra Seat Belt 2010 Toyota Tundra Seat Belt